Skip navigation

DSpace

機構典藏 DSpace 系統致力於保存各式數位資料(如:文字、圖片、PDF)並使其易於取用。

點此認識 DSpace
DSpace logo
English
中文
  • 瀏覽論文
    • 校院系所
    • 出版年
    • 作者
    • 標題
    • 關鍵字
  • 搜尋 TDR
  • 授權 Q&A
  • 幫助
    • 我的頁面
    • 接受 E-mail 通知
    • 編輯個人資料
  1. NTU Theses and Dissertations Repository
  2. 工學院
  3. 化學工程學系
請用此 Handle URI 來引用此文件: http://tdr.lib.ntu.edu.tw/jspui/handle/123456789/16660
標題: 利用Rhodococcus erythropolis NTU-1細胞破乳化
De-emulsification by Rhodococcus erythropolis NTU-1
作者: Shih-Wen Wang
王詩雯
指導教授: 劉懷勝
關鍵字: 破乳化,Rhodococcus erythropolis NTU-1菌株,原油回收量,乳化液,Tween80,
Emulsion,tertiary oil recovery,de-emulsification,Rhodococcus erythropolis NTU-1,
出版年 : 2014
學位: 碩士
摘要: 本研究目的主要探討R. erythropolis NTU-1之破乳化的特性,其能利用此菌株使油水乳化液在短時間內能分離出油。
以菌液破乳化的研究結果發現,乳化劑Tween80可以將正十六烷與水互相混合形成白色乳化液,利用NTU-1菌液可以在24小時內可以回收85%以上的正十六烷,破乳化效率也高達90%。同時發現在O/W/T為2~8/1/0.01,並不影響最適添加NTU-1菌液量(3 mL,OD600=1)。
若以烘乾經正十六烷培養的NTU-1結塊細胞破乳化,該細胞粉末雖然不具活性,但仍保有很高的疏水性,亦可以使破乳化效果在12小時內就達85%以上且回收85%以上的正十六烷。同時,在O/W/T為2~9/1/0.01,並不影響乾燥NTU-1結塊的最適添加量(0.03 g)。經實驗可估算出1 g的乾燥結塊約可以回收250 mL 的正十六烷。
實驗發現在低乳化劑濃度0.2%或油/水(O/W)比值越小或高破乳化溫度下,可以提高破乳化程度及縮短破乳化時間。另外,藉由改變不同乳化劑體積,發現最適添加NTU-1細胞(不論是菌液或是乾燥結塊)與Tween80體積存在面積比(量的n=2/3次方)的關係。
由此可知,NTU-1菌液或是烘乾後的NTU-1結塊皆具有很好的破乳化能力,可以在24小時就回收80%以上的正十六烷,此項成果確實在三級原油回收方面,提供一個相當具有競爭性及發展性的方法。
This report investigated the feasibility of applying Rhodococcus erythropolis NTU-1 that possessed de-emulsifying ability to recover oil from oil-in-water (O/W) emulsion.
Suspended NTU-1 cell reach de-emulsification efficiency up to 90% and recovered 85% oil in 24 hr. Besides, the optimal amount of NTU-1 cell addition was 3 mL (OD600=1) when Oil/Water/Tween80 was 2~8/1/0.01.
Heat-dried bioflocculi also were tested because of its convenience in practical application. Dried bioflocculi retained its high hydrophobicity, resulting in more than 85% de-emulsification and 85% oil recovery in 12hr. When Oil/Water/Tween80 volume is 2~9/1/0.01, the optimal amount of dried NTU-1 was 0.03 g. It was estimated and calculated that 250 mL oil might be recovered by 1 g dried bioflocculi.
Lower Tween80 concentration or O/W ratio and higher temperature, better de-emulsification and oil recovery in less time. In addition, the optimal amount of NTU-1 for de-emulsification, for both suspended and dried NTU-1, was proportional to the amount of Tween80 to the power of 2/3, indicating a surface area dependent behavior.
These experimental results showed that NTU-1 in MSM or dried bioflocculi had a potential role in enhancing tertiary oil recovery process.
URI: http://tdr.lib.ntu.edu.tw/jspui/handle/123456789/16660
全文授權: 未授權
顯示於系所單位:化學工程學系

文件中的檔案:
檔案 大小格式 
ntu-103-1.pdf
  目前未授權公開取用
10.8 MBAdobe PDF
顯示文件完整紀錄


系統中的文件,除了特別指名其著作權條款之外,均受到著作權保護,並且保留所有的權利。

社群連結
聯絡資訊
10617臺北市大安區羅斯福路四段1號
No.1 Sec.4, Roosevelt Rd., Taipei, Taiwan, R.O.C. 106
Tel: (02)33662353
Email: ntuetds@ntu.edu.tw
意見箱
相關連結
館藏目錄
國內圖書館整合查詢 MetaCat
臺大學術典藏 NTU Scholars
臺大圖書館數位典藏館
本站聲明
© NTU Library All Rights Reserved