請用此 Handle URI 來引用此文件:
http://tdr.lib.ntu.edu.tw/jspui/handle/123456789/67368
標題: | 交錯潤濕性表面於紅銅圓管表面之冷凝熱傳研究 Effect of Interlaced Wettability on a Horizontal Copper Tube in Condensation Heat Transfer |
作者: | Hsin-Ting Lin 林信霆 |
指導教授: | 陳炳煇(Ping-Hei Chen) |
關鍵字: | 冷凝熱傳,表面改質,交錯潤濕性,溶膠-凝膠法,不可凝結氣體, condensation heat transfer,surface modification,interlaced wettability,sol-gel method,non-condensable gas, |
出版年 : | 2017 |
學位: | 碩士 |
摘要: | 本研究以外直徑25mm的紅銅圓管作為熱傳介質,使用溶膠凝膠法及低表面能物質塗覆作為改質方法,並以模切膠帶作為遮罩製備出以超疏水表面為基底之異質潤濕性表面,於含不可凝結氣體之環境下探討其對冷凝熱傳之影響。改質表面之接觸角大於150゚,未改質之紅銅表面經烘烤後接觸角約為100゚,而改質條紋之寬度分別為1.5mm、2.5mm,4.5mm、5.5mm,未改質條紋寬度則固定在0.5mm。
實驗結果顯示改質均質超疏水表面在低過冷度時相較於未改質表面之冷凝熱傳係數有30%左右的成長,當過冷度大於4 K時,均質超疏水表面將出現浸潤轉變,此時冷凝熱傳係數與未改質表面相近。而當改質條紋為1.5mm,過冷度為9 K時,交錯潤濕性表面對於冷凝熱傳表現有較好的增強效果,然而當表面過冷度低時,交錯潤濕性表面之冷凝熱傳係數均不如均質超疏水表面。 This study investigated the effect of tube surfaces with superhydrophobicity-based interlaced wettability on steam–air mixture condensation. Experiments were conducted on various types of surface with different modified strip widths varied from 1.5mm to 0.55mm. The contact angle of the modified surface is about 150゚, and the contact angle of the copper surface after heated is about 100゚. The experimental results revealed that the condensation heat transfer coefficient on the homogeneous modified surface could be 30% higher than the plain copper surface when the wall subcooling is lower than 4 K. However, when the wall subcooling is higher than 4 K, the condensation heat transfer coefficient on the homogeneous modified surface is almost the same as the plain copper surface. When the wall subcooling is 9 K, the condensation heat transfer coefficient of interlaced wettability surface with modified strip width of 1.5mm is higher than the modified homogeneous surface. However, the condensation heat transfer performance cannot be improved by interlaced wettability surface when the wall subcooling is low. |
URI: | http://tdr.lib.ntu.edu.tw/jspui/handle/123456789/67368 |
DOI: | 10.6342/NTU201702500 |
全文授權: | 有償授權 |
顯示於系所單位: | 機械工程學系 |
文件中的檔案:
檔案 | 大小 | 格式 | |
---|---|---|---|
ntu-106-1.pdf 目前未授權公開取用 | 3.64 MB | Adobe PDF |
系統中的文件,除了特別指名其著作權條款之外,均受到著作權保護,並且保留所有的權利。